TheAudi R10 TDI (Turbo Direct Injection) is asports prototype designed and built byAudi in partnership withDallara.[8] Built to theLe Mans Prototype 1 (LMP1) regulations, the R10 was highly successful throughout its career; the R10 became the firstdiesel-powered car to win the24 Hours of Le Mans in 2006, in what would be the first of three 24 Hours of Le Mans wins.[6] Unveiled to the public on 13 December 2005 in Paris, the R10 would go on to win the2006 24 Hours of Le Mans just 200 days later.[9]
The R10 was eventually replaced by theR15 TDI at the conclusion of the2008 American Le Mans Series.Colin Kolles ofByKolles Racing (known then as 'Kolles') fielded the car for two more years at Le Mans and for a single year in the2009 Le Mans Series.[10][11]
The R10's predecessor, theR8 Le Mans Prototype, was an open-cockpit design based on experience gained with theAudi R8R.[12] The R8R's sibling, the closed-cockpit R8C, was not as successful as the R8R and Audi chose open-cockpits as their design philosophy, this remained the case until 2011, when theR18 TDI was unveiled with a closed-cockpit.[13] A key difference between open- and closed-cockpit designs such as theBentley Speed 8 was that the closed-cockpit prototypes of the LMGTP class ran with narrower tyres, but had larger air restrictors and thus produced more power compared to its fellow open-cockpit LMP1 cars.[14]
The R8 proved to be one of the most successful sports prototypes of all time, dominating the LMP900 class from its introduction in 2000, scoring 63 victories from 79 races.[15] Eventually, weight and air restrictor penalties resulted in the R8's competitors becoming increasingly closer on pace, for the 2005 edition of the 24 Hours of Le Mans the R8 was forced to carry 50 kg (110 lb) extra inballast and had smaller air restrictors.[16] These changes to the regulations meant that the V8 in the R8 LMP was becoming obsolete.[17][18] The2005 Le Mans Endurance Series finale atIstanbul saw the end to the R8's racing activities in Europe, however, akin to what was done with the R8R, the R8 replaced the R10 following the latter's debut at the2006 12 Hours of Sebring until the2006 24 Hours of Le Mans.[19][20]
The R8 LMP was renowned for its serviceability, especially the rear assembly, which was nicknamed "Hinterwagen".[21] The serviceability trend continued with the R10, with not only the rear bodywork being removable but the front crash structure too.[22] The R10 carried over the R8'scarbon fibremonocoque andaluminium honeycomb, with the plastic bodywork replaced by a carbon-fibre composite construction, necessitated by the increased weight of the V12 compared to the previous V8.[22]
Audi was not the first to campaign a diesel-powered car at the 24 Hours of Le Mans, with French brothers Jean and Jacques Delettrez being the first to field a diesel. They entered the1949 24 Hours of Le Mans with a car that had bodywork byDelage and was powered by a 4.4 L (268.5 cu in)inline-6 producing 70 PS (69 hp; 51 kW). They retired after completing 1,660 km (1,031 mi), having run the starter motor battery dry after attempting to travel back to the pits after the car had run out of diesel.[23]
After retiring with valve failure in 1951, the Delettrez brothers were the last diesel-powered entrant until privateers Taurus Sports Racing entered the2004 24 Hours of Le Mans with aLola B2K/10 that was powered by a 4,921 cc (300.3 cu in)V10 TDI from aVolkswagen Touareg.[23] The first success of a diesel-powered race car was aBMW 320d that won the1998 24 Hours of Nürburgring.[23]
In January 2002, head of Engine Technology at Audi SportUlrich Baretsky sat down over a beer withAutomobile Club de l'Ouest officials Daniel Poissoneaux and Daniel Perdrix in Ingolstadt to discuss the direction racing would take in the future.[24] During that conversation Baretsky realised that 50% of European cars on the market were powered by diesel engines,[17] prompting Baretsky to suggest to head of Engine Development at Audi Wolfgang Hatz the idea of a diesel-powered race car. Hatz supported the idea, citing how the technologies pioneered in a diesel-powered race car could be carried over into a road car, or vice versa, such asFSI technology which was being used in the R8 LMP's and Audi's road car engines.[25][17] Wolfgang Ullrich, head of Audi Motorsport, also saw the potential in a diesel-powered race car, as theAmerican Le Mans Series was part of Audi's competition calendar, and Audi was looking to introduce its diesel road car range to theUnited States.[26] Ullrich wanted to change the stereotype of diesels being dirty[27] and "oil-burners",[28] and that he "wanted to push the sportiness of the diesel", and "the best way to do that was through motor sport [sic]."[20] Then-chairman of the board of Audi AGMartin Winterkorn reiterated this during the car's presentation in Paris in 2005, saying "The Le Mans project will help our technicians to extract even more from TDI technology".[29]
During the2004 24 Hours of Le Mans, Baretsky met with the then-chairman of the supervisory board of Volkswagen,Ferdinand Piëch, who gave the project the go-ahead.[20] The first engine prototype was a production-based Audi V8 with a similar bore and stroke to the V12 intended for use in the race car, and its first runs on thedyno came in early 2005.[25] By the time of the R10's unveiling in December of that year, the engine was said to have completed around 1,000 hours on the dyno.[22] The engine presented several unique challenges for Audi, one of which was the construction of theengine block. Wolfgang Appel, director of Vehicle Technology at Audi, compared the task to theApollo program, saying "In the beginning they [the Americans] did not know what was going on, nor did we!"[22] At the time, all of Audi's road car diesel engines usedvermicular cast iron, and head of Audi Diesel Engine Development Richard Bauder suggested that like the road cars, the race car block should be machined from cast iron.[20] Baretsky rejected the idea on the grounds that a cast iron block was too heavy, opting for analuminium-siliconalloy block instead.[25][22] TheBoschMotronic MS14engine control unit (ECU) was also bespoke, with Bosch having never written software for an engine this powerful.[20] A Boschcommon rail fuel injection system withpiezoelectric injectors[30] delivered fuel into the cylinders at over 1,600 bar (23,206 psi), combined with aGarrettturbocharger for each bank (limited to 2.94 bar (42.6 psi)), resulted in a power output of over 650 PS (478 kW; 641 hp) between 3,000 and 5,000 rpm and a torque output of 1,100 N⋅m (811 lb⋅ft).[17]
Dow Automotive also developed and manufactured a specialiseddiesel particulate filter (DPF) for the R10.[22] The particulate filter consisted of a chemically treatedceramichoneycomb structure, which had a distinct microstructure that reduced weight and had a highporosity. The filters were so efficient that exhausts from the engine were practically transparent, and the exhaust note was around 5 dB quieter than the R8, at 105 dB.[6][31]Allan McNish said the exhaust was so quiet that above 161 km/h (100 mph), the sound of wind rushing by was louder than the engine itself, making downshifting hard to do by ear.[8][32] A complication with the diesel particulate filters arose when deciding where to mount them; Audi eventually settling on mounting them aftwards at the end of the exhaust pipes.[25] This somewhat disturbed the R10'sweight distribution, with Baretsky commenting that "We'd be happier to have them [the filters] closer to the engine, but this would have put them in the middle of the rear axle".[25] After the 2006 race, Baretsky was said to have wiped the inside of the No. 8's exhaust pipes whilst the car was inparc fermé, and Ralf Jüttner, team director ofJoest Racing, remarked that afterwards "the napkins were as pristine-white as before".[33]
The immense power produced by the engine also required a newgearbox. A favourable torque curve meant that a 6-speed like the one found in the R8 was unnecessary, andXtrac provided a 5-speedpneumatically-actuatedsequential with aZF Sachs ceramic clutch, and Megaline supplied the gearbox control system.[17] Despite the vastly superior torque, the new gearbox is lighter than the R8's gearbox. It is a thin walled aluminium casting, as opposed to its predecessor'sRicardo magnesium case.[22] Bosch also supplied the car with itsAcceleration Slip Regulation unit.[17]
Along with the engine's high power and torque figures, its efficiency was among the highest in racing engines of its era. The car's fuelkilometrage at the 2006 and 2008 24 Hours of Le Mans was 41.05 L/100 km (5.73 mpg‑US), and 45.56 L/100 km (5.16 mpg‑US), respectively (the latter race being hampered by rain).[34][22] In comparison, a 2007Formula One car was said to have a fuel efficiency of around 75 L/100 km (3.14 mpg‑US).[35] This efficiency meant that the R10 was able to run longer stints than the R8,[17] and proved to be integral to Audi's success at theCircuit de la Sarthe. Victory at the2006 race saw Audi run 4 more laps per stint than its closest competitor, the petrol-poweredPescarolo-Judd, and victory at the2008 24 Hours of Le Mans came courtesy of the dieselPeugeot 908 HDi FAP needing to pit a lap earlier than the R10 to take on fuel, despite being a quicker car.[34][7]
The R10's debut season sawJoest Racing handling the R10's Le Mans duties, and partner withChampion Racing at Sebring.[36] Champion Racing continued to field the car in theAmerican Le Mans Series, although the R10 was replaced by the R8 following Sebring and was not reintroduced until the fifth round of the season at the2006 Utah Grand Prix.[20][37] Sebring acted as a testing ground for Joest Racing as preparations in Europe began for that year's 24 Hours of Le Mans in June.[20][17][6] Ullrich said the rationale behind fielding the older R8 was that the R10 project required more development, saying "We used Sebring as a testing ground, but until Le Mans was done we used the existing R8 in the US".[20]
Joest Racing's Le Mans campaign did not start off smoothly, with an issue with the piezo-electric injectors surfacing. The injectors behaved unusually during qualifying and the race, because of the constant development and modifications to the engine throughout 2006, Audi would be in constant communication with Bosch to try and resolve the problem.[20][38] A temporary measure implemented was to limit the distance covered by each engines through qualifying, so as to preserve them for the race.[20][38] Despite this,Rinaldo Capello put the No. 7 R10 on pole with a time of 3:30.466, alongside him was the sister No. 8, withMarco Werner setting a time of 3:30.584, over 2 seconds faster than the nearest petrol-hybridPescarolo-Judd C60s, which lined up in the second row.[39]
The injector problem resurfaced during the race, with the No. 7 car coming into the pits in the fourth hour to replace an injector that had failed. The faulty injector held the car up for twenty minutes, because the software could not pinpoint exactly which injector had failed, only which bank it was in.[20] Audi eventually replaced the entire right-hand bank of injectors,[40] and the No. 7 rejoined in 14th place, six laps behind the leading No. 8.[41] Repairs to fix contact with lapped traffic andturbo failure cost the No. 7 almost an hour in the pits, effectively ruling it out for the overall win.[42]
The No. 8 was not affected by injector issues, with its only unscheduled appearance in the pit lane coming early in the morning of the following day for a gear cluster change.[43] The No. 8 went on to take the overall win in a record 380 laps @ 215.4 km/h (133.8 mph), 4 laps ahead of the No. 17 Pescarolo-Judd, and the No. 7 sister Audi rounded out the podium, finishing 13 laps behind the leader.[44][45][33] Kristensen also set the record for longest stint at the time in an LMP1 car, covering 16 laps in a single 90 L (23.8 US gal) tank of diesel,[7] along with setting the fastest lap, clocking a 3:31.211 en route to his podium finish.[8][43] The R10's victory was the first triumph of a diesel-powered race car in a major event since a Cummins Special qualified on pole for the 1953Indianapolis 500, and the first diesel race car to win the 24 Hours of Le Mans.[17][33][46] Pirro also extended his consecutive podium finishes to eight.[47]
Following Audi's success at Le Mans, the R10 made a brief appearance in theUnited Kingdom for an exhibition race.Allan McNish was pitted against aHarrier Jump Jet at theRAF Wittering base during the 2006Goodwood Festival of Speed.[48] The R10 raced the jet from a standing start over a 1 km (0.6 mi) stretch of tarmac, and was the first of the two to reach 241 km/h (150 mph), shortly before the Harrier overtook the R10 and became airborne.[49] McNish commented "It was essentialiy a 'fun' race," and that "when a racing driver and a pilot get together it quickly becomes serious".[49]
Champion Racing assumed responsibility for the R10's campaign in the American Le Mans Series as Audi Sport North America.[50][51]Frank Biela andEmanuele Pirro were the No. 1 R10's regular drivers for the season, withAllan McNish andRinaldo Capello regulars at the helm of the No. 2.[51][50]
The R10 was quick straight away, withRinaldo Capello breaking the Sebring lap record on the last day of winter testing, setting a time of 1:47.308.[52] Capello, alongsideTom Kristensen andAllan McNish, piloted the No. 2 R10 for the opening round of theAmerican Le Mans Series withMarco Werner,Emanuele Pirro, andFrank Biela piloting the sister No. 1 R10.[53]
The No. 2 R10 broke the track lap record in qualifying en route to pole position at Sebring in an Audi front row lockout, but was forced to start from the pit lane because of anintercooler failure.[8][54] The No. 2 dominated the race, leading every single lap of the race, givingTom Kristensen a then record-breaking 4th overall win at Sebring.[55] The No. 2 was Audi's sole podium finisher, the sister No. 1 suffering from cooling issues caused by tyre debris blocking aradiator. The No. 1 was retired four hours into the race as a precautionary measure.[54]
At the inaugural2006 Utah Grand Prix, Capello and McNish went into the race holding a comfortable lead in the championship standings as the R8 remained competitive, having been run for the previous three rounds.[37] Biela qualified on pole, setting a time of 2:21.554.[56] Biela lost the lead on the first lap to McNish at turn 4 after going wide, and run wide again at the final turn, losing more places. McNish maintained and extended his lead until he came into the pitlane on the 25th lap to swap seats with Capello. Capello regained the lead on the 49th lap but was forced to make an unscheduled pit stop with a tyrepuncture on the 59th lap, ruling his crew out of overall contention. Pirro in the sister R10 made his way through the field following Biela's earlier mistakes, setting the fastest lap on the 51st lap en route to retaking the lead.[56]Lucas Luhr in the No. 6Porsche RS SpyderLMP2 followed closely behind, and an attempt to overtake Pirro on the last lap did not materialise, with Luhr finishing 0.314 seconds behind Pirro.[57]
At the next round, the2006 Portland Grand Prix,Butch Leitzinger put his No. 16Lola B06/10 on pole with a 1:03.101, 0.132 s ahead of the No. 20 of his teammate,Guy Smith.[58] The No. 2 R10 of Capello and McNish was the only Audi to crack the top four, qualifying behind the two Lolas with a 1:03.421, and the No. 1 started 5th with a 1:03.813.[37] The two Audis swept the race, with both cars finishing two laps ahead of the nearest Lola.[59] McNish took his 4th outright victory of the season, extending his championship lead to 39 points.[60]
The governing body of the American Le Mans Series, theIMSA, made changes to the regulations before theGenerac 500 atRoad America, allowing the petrol-powered LMP1 cars to run 65 kg (143 lb) less than the diesel-powered cars.[61] This meant that the petrol-powered LMP1s weighed 860 kg (1,896 lb), with the R10's weight unchanged at 925 kg (2,039 lb). The petrol-powered LMP1s also received a 5 L (1.32 US gal) fuel tank volume increase.[61][62]
Despite thebalance of performance shifting out of the R10's favour, they scored a front row lockout in qualifying. The No. 2 of McNish was the fastest of the two, setting a new track lap record with a 1:49.181, 1.386 seconds ahead of the sister No. 1.[63] Shortly after the lights went out for the race,James Weaver of the No. 16 Lola B06/10 made contact with Biela, sending Biela into the gravel, causing him to drop down to 22nd after the first lap.[64] The No. 7 RS Spyder of Luhr andRomain Dumas traded the lead with the No. 2 of McNish and Capello, however, a late restart enabled Pirro to take the chequered flag, four-tenths ahead of Capello.[65][64] Capello
Rain cancelled qualifying for the2006 Grand Prix of Mosport, and qualifying times were taken from each car's fastest time in practice. Weaver and Leitzinger qualified on pole, with a 1:06.843, with McNish and Capello alongside them in second.[66] The No. 20 Lola B06/10 ofChris Dyson took the lead on the first lap, holding it until he had to pit on lap 27, remaining at the front until lap 46.[67] The No. 2 of Capello took the lead from there, losing it briefly on lap 62 for the driver change, with McNish racing with the Dyson Lolas of Leitzinger and Smith.[67] Despite McNish suffering from loss of grip due to picking upmarbles on his tyres, which allowed Leitzinger to overtake him briefly, McNish retook the lead and finish first, 2.794 s ahead of the No. 20 Lola of Smith.[68][69] With this victory, McNish and Capello extended their championship lead to 49 points, giving them the driver's championship.[70] This was because even if Weaver and Leitzinger, their closest competitors, won the next two rounds, McNish and Capello were still driver champions since they scored more victories.[70]
Petit Le Mans was their next race, with McNish lining up second on the front row of the grid next toNicolas Minassian, who set a 1:10.829 in hisCreation CA06/H.[71] Minassian led the field until Werner in the No. 1 Audi overtook him on the 25th lap, with Werner himself then being overtaken by McNish in the sister No. 2.[71] McNish and Capello battled withStefan Johansson and Luhr in their No. 15Zytek 06S and RS Spyder respectively, exchanging the lead several times.[71] Smith in the No. 20 Lola B06/10 started to close in on Biela, but rear suspension failure sent him into a heavy shunt just before turn five, and a full-course yellow was shown as the debris was cleaned up.[72][73] Johansson's co-driver, Haruki Kurosawa, briefly led on the 103rd lap before Biela retook the lead on the 104th lap.[71] McNish later reeled Biela in, retaking the lead on the 155th lap, a lead he held until a brief interruption by Johansson from laps 258–267, taking the chequered flag.[71][74] The sister No. 1 was close behind towards the finish, but contact with a backmarker 13 minutes before the end damaged the front suspension, forcing Werner to pit and lose time.[75] The No. 1 crossed the finish line to place seventh overall, fifth in class.[71][74]
At the season finale atLaguna Seca, the No. 2 and No. 1 Audi qualified fourth and fifth, setting a time of 1:14.116 and 1:14.351, respectively.[76] Johansson set a new lap record when he put hisZytek 06S on pole with a 1:13.731, over three tenths ahead of the No. 2.[76] The beginning of the race saw both Audis lose significant time, Pirro in the No. 1 pitted on the third lap after an onboard camera became loose and fell into the footwell of the car, and McNish was issued with astop-and-go penalty after causing contact going into Laguna Seca's famous "Corkscrew", forcing the team to replace his front fascia.[77] Asafety car allowed both cars to unlap themselves, and McNish recaptured the lead on lap 108,[78] a lead he held until the end as his competitors had to pit again in the final hour for fuel, something which both Audis did not need to because of the engine's efficiency was combined with fuel-conserving driving techniques.[77] The sister No. 2 finished 18.579 seconds behind, giving Audi their third 1–2 finish of the season.[77] With the completion of the 2006 season, Audi became the first manufacturer to win every single race of the LMP1 class in the American Le Mans Series.[77]
Several minor refinements were made to the R10; namely lighterparticulate filters, a more precisesuspension, an improvedengine control unit from Bosch, and a refinedtyre construction from supplierMichelin. The chassis and engine remained the same from the previous year's car, however, the engine'spower band was improved to make the car more driveable and frugal.[79][80] Two drivers,Lucas Luhr andMike Rockenfeller, were poached from fellow German marquePorsche, the former having previously driven aPorsche RS Spyder in theAmerican Le Mans Series and the latter having previously driven aPorsche-poweredGrand-AmDaytona Prototype.[81]
Audi sent three cars to the75th 24 Hours of Le Mans. Two were run under the "Audi Sport North America" banner, and one under "Audi Sport Team Joest", withJoest Racing responsible for all three cars.[82][83]
Driver lineups largely remained the same, the No. 1 R10 driven byFrank Biela,Emanuele Pirro andMarco Werner, the No. 2 byDindo Capello,Allan McNish andTom Kristensen, and the No. 3 byLucas Luhr,Alexandre Prémat andMike Rockenfeller. Kristensen was replaced byMattias Ekström for the test days following Kristensen's severe crash at the opening round of the2007 DTM season in April.[84] Ekström swapped seats with Rockenfeller as Rockenfeller'sstature was similar to that of Capello and McNish's. Kristensen was left to recover and following a brief test later atBrands Hatch, he was cleared to race by doctors.[84][85] Kristensen's recovery meant that Ekström was not needed anymore, and he returned to Sweden.[84]
The No. 8Peugeot 908 HDi FAP ofSébastien Bourdais,Pedro Lamy, andStephane Sarrazin topped the timing tables during testing, posting a 3:26.707,[86] over a second and a half faster than the second-placed No. 2 R10 of Biela, Pirro, and Werner.[85] This pace carried over into the first qualifying session, with Peugeot and Audi battling fiercely for pole position as rain was forecast the following day.[87] The first session was interrupted by rain and twored flags, with Sarrazin eventually taking provisionalpole away from McNish on his finalflying lap, setting a 3:26.344, just over half a second ahead of McNish.[87] Theweather forecast proved to be accurate, with all of qualifying the next day taking place in wet conditions; Bourdais duly set the fastest time, a 4:01.928.[88] Since Sarrazin's time set in dry qualifying had not been beaten, the No. 8 car was on pole for the race, with the No. 2 of Capello, McNish, and Kristen alongside them.[89][90] The No. 1 and No. 2 R10 of Biela, Pirro, Werner, and Luhr, Prémat, and Rockenfeller lined up fourth and fifth, respectively.[90]
Bourdais led the off field in his 908 HDi but ran wide on the first lap at the Dunlop chicane and handed over the lead to Capello,[91] and soon the Audis were running in the top three positions. Rockenfeller was one of the first victims of the still-damp track, spinning and crashing the No. 3 R10 within the first couple of hours into anArmco barrier near Tertre Rouge, destroying a significant portion of the rear assembly of his R10.[92] Rockenfeller attempted to repair his car, but with hisdifferential only powering a single wheel, he was eventually coerced by the marshals to retire.[92][82]
Capello, along with Kristensen and McNish, steadily build up a lead after Bourdais ran wide, a lead they held despite an interruption in the seventh hour by a safety car after Werner's No. 1 R10 made contact withJan Magnussen'sChevrolet Corvette C6.R.[93] Capello's co-driver McNish set the fastest lap of the race in the early hours in the following morning, clocking a 3:27.176.[94] Capello led the No. 1 R10 in his No. 2 R10 by three laps as the race passed the sixteenth hour mark, with Werner having lost time due to an unscheduled pit stop for a nose change after his contact with Magnussen.[93][95] Shortly afterwards, an improperly fastened wheel nut from Capello's last pit stop worked itself loose,[96] resulting in Capello's left rear wheel coming off, sending him into a spin and a large shunt into the barriers at the Indianapolis curve.[97][98] Rod Bymaster, Audi Motorsport North America manager, remarked that "You know there's something wrong when the rear wheel passes the car".[96] Capello was unharmed, and like Rockenfeller, attempted to restart the car before eventually retiring at 6:20 a.m. local time.[99] Biela in the No. 1 R10 pitted shortly after, handing over the car and lead to Pirro, who extended his lead to four laps ahead of the second placed No. 7 908 HDi ofMarc Gené.[99] Pirro had a lengthy pit stop following his first stint, due to precautions ensuring that the same wheel nut failure that crippled Capello did not happen to Pirro.[99]
Many teams forecasted that the final hours were to be raced under wet conditions, and shortly before 1:00 p.m. local time rain began to fall on track.[99] Biela, who still led the race at the time, ran wide at the first chicane on theMulsanne Straight, before pitting for wet weather tyres, replacing the rear bodywork and handing over the wheel to Werner.[100][99] Second-placed Bourdais, who was six laps down on Biela in his No. 8 908 HDi, also came in for wet tyres.[100]Nicolas Minassian relinquished second position shortly before the rain fell, coming into the garage with engine problems.[99][100] The rain became progressively heavier, with Werner repeating the same mistake Biela made at the first chicane on the Mulsanne Straight, running straight on but not suffering any damage.[101] Minassian's No. 7 908 HDi rejoined in fourth place, but after a single lap around the circuit he came back into the garage to finally retire with electrical problems[102] just over an hour from the finish.[99][101] The safety car came out shortly after, and Bourdais in the No. 8 908 HDi came into the garage.[99] The safety car came in towards the end of the hour, allowing for a couple of laps under green flag conditions.[103] The heavy rain continued, and Biela slowed down accordingly, lapping the circuit a minute and a half slower than what he had under dry conditions.[99] Bourdais re-emerged from his garage shortly before the safety car came in,[99] and stopped at the final chicane of the circuit on the beginning of the final lap in order to cross the finish line with the leading cars.[103] Biela went on to take the chequered flag, and give Audi their fourth consecutive win at Le Mans, covering 5,029 km (3,125 mi) at an average speed of 209.15 km/h (129.96 mph), despite more than two hours and a half under the safety car.[104][98][86] The R10 also set the highest top speed recorded of 351 km/h (218 mph) since theJaguar XJR9 reached 389 km/h (242 mph) at the1989 24 Hours of Le Mans.[86]Pirro remarked that the team "had nine stressful hours with the Peugeot right behind us", but "the more you suffer, the greater the pleasure."[105] Wolfgang Ullrich, head of Audi Motorsport, agreed, saying "This victory is the most difficult we have had at Le Mans", and that the team was "put under pressure by Peugeot right to the end of the race."[106] Pirro also extended his consecutive podium finishes to nine, a record yet to be equalled.[47]
Audi committed to a second season of theAmerican Le Mans Series, with Baretsky reiterating the link between Audi's motorsport developments and Audi's production cars, saying "I believe we will be able to share the things that we developed specifically for motorsport with production in the future."[7] Again,Champion Racing handled the team's American Le Mans Series campaign, with support fromJoest Racing at Sebring and Le Mans.[107][108]
The replacement ofFrank Biela byMarco Werner, who largely played a development role in 2006, was the only change in the driver lineup for Audi.[107] Changes to the racing calendar included the addition of three new races, one inSt. Petersburg, Florida, one inLong Beach, California, and one inDetroit, Michigan.[109] ThePortland Grand Prix was dropped from the calendar, resulting in a total of twelve races for the season.[109] Changes to the technical regulations included a 10% reduction in size of the R10's fuel tank from 90 L (23.8 US gal) to 81 L (21.4 US gal), and theLMP2 cars received a weight reduction of 150 kg (331 lb).[110]
The R10 proved to be still the car to beat atSebring, continually topping the timing charts during practice. However, a mistake by Capello in the No. 1 during Thursday night practice meant that his car suffered heavy damage, returning to the pits missing almost its entire left side. Capello himself was unharmed, although the damage sustained required a full rebuild in order for it to be ready for the race.[111][112]
Both R10s started on the front row for the2007 12 Hours of Sebring, with Werner in the No. 2 setting a 1:44.974, breaking the track lap record by almost a second and edging out Capello in the No. 1.[113][114] Ared flag briefly interrupted qualifying, and Capello, who had just started his secondflying lap, felt that it had negatively affected his qualifying in performance as he could not get his tyres up to temperature after the restart.[114] Capello overtook Biela a couple of laps into the race, as Biela had to slow down for a slowerGT2 car, and Biela also suffered from a left rearpuncture shortly after the hour and a half mark, losing several positions and falling to seventh.[115] Kristensen led until the fifth hour, when he pitted to change his car's battery. As a result of the pit stop that lasted almost fifteen minutes, Kristensen dropped down to seventh, and had to come in again just a half-hour later for another battery,starter motor, anddashboard.[115] Kristensen pitted yet again another half-hour later for another starter motor. Kristensen, Capello, and McNish eventually finished fourth overall, second in LMP1, behind the two new LMP2Acura ARX-01as, and the No. 2 R10 of Biela, Werner, and Pirro took the overall victory having taken and held the lead from the penultimate hour.[116][115] Although the R10 set the fastest lap of the race, the No. 7Porsche RS Spyder ofTimo Bernhard,Romain Dumas, andHélio Castroneves and the No. 26 Acura ofBryan Herta,Dario Franchitti, andTony Kanaan frequently exchanged the lead with the R10 throughout the race,[117] highlighting the competitiveness of the LMP2 cars following their 150 kg (331 lb) reduction in weight.[116] Despite the strong competition, Audi's win at Sebring was the German marque's eighth in a row.[118]
At the firststreet circuit of the season, the inauguralGrand Prix of St. Petersburg, the R10s faced stiff competition from the lighter, nimbler LMP2 cars, which had the edge over the R10 in the corners but fell behind on the straights.[119] Come qualifying, bothTeam PenskePorsche RS Spyders were quicker than the Audis, withRomain Dumas in his No. 7 taking pole, lowering the track record with a 1:03.039, the other Penske RS Spyder lining up second, withRyan Briscoe close behind, posting a 1:03.189.[120] McNish was the fastest of the Audi drivers, piloting the No. 1 R10 to third on the grid with a 1:03.415, a LMP1 record. Werner was the faster of himself and Pirro in the No. 2 R10, however, could not break the 1:04 mark, posting a 1:04.139 and settling for seventh on the grid.[120] Come race day, McNish in his No. 1 R10 attempted a risky move into turn one, hoping to catch the Porsches in front of him off-guard. He made contact with Dumas, the latter suffering from apuncture.[121] Dumas ended up two laps down, and McNish was duly reprimanded with a stop-and-go penalty which dropped him down to eighth.[121]Marino Franchitti led the way briefly in hisAcura ARX-01a before Briscoe made contact with the Acura whilst attempting to pass Franchitti, causing Franchitti to hit the tyre wall.[121] Franchitti and his teammate Herta could not recover from that accident; a lowly 21st was their end result.[122] Briscoe himself was also handed with a stop-and-go penalty for the incident, although finished third overall despite yet another penalty when he forgot his goggles during a pit stop.[122] McNish retook the lead on the nineteenth lap, and by the beginning of the 36th lap it was an entirely Audi affair. McNish took the chequered flag with Werner in the No. 2 close behind, just under half a second separated the two. A yellow flag towards the closing hour of the race was brought out forTomas Enge, who whilst leading the LMGT2 category in hisFerrari F430 GTC shunted heavily at turn 3.[123] This did not hinder the Audis, with both cars finishing more than twenty seconds ahead of the Porsches.[124] McNish's fastest lap of 1:04.725 set a new LMP1 lap record, although was not quick enough for overall honours, with Briscoe slightly faster in a 1:04.340.[122]
The next destination of the season, the2007 Toyota Grand Prix of Long Beach was also a street circuit, nicknamed the "Monaco of the United States" due to its proximity to thecoastline.[125][126] Capello was the fastest of the Audi drivers, posting a 1:12.713 to qualify fourth. Pirro in the No. 2 was two places back, clocking a 1:12.911. Franchitti, who had previously raced at Long Beach during the2002 CART season qualified on pole with a 1:11.838, the only man under 1:12.[127] Both Audis found themselves out of contention for the own reasons; Capello encountered brake trouble in the opening laps that hindered his pace on the tight circuit.[128] However, McNish in the No. 1 would briefly take the lead after Franchitti, who had been leading so far, lost a gamble on strategy and pitted during a full-course yellow. McNish held Franchitti up in an attempt to allow Pirro in the sister No. 2 past; Pirro promptly took the lead just over three-quarters of an hour into the race. Dumas, who had been running behind Pirro, quickly inherited the lead after Pirro collided with aFlying Lizard Motorsports911 GT3 RSR.[129] The accident forced Pirro to pit with a puncture, ruling him out of overall contention.[130] McNish finished seventh after his earlier gremlins and a late pit stop cost him time.[128] The sister R10 finished ninth, a lap behind.[131] All the podium spots were occupied by Porsche RS Spyders, marking the first time a single marque had populated every single podium spot, as well as the first LMP2 podium lockout.[132][133] With Dumas' victory, Audi's winning streak in the American Le Mans Series was finally ended, following nine consecutive overall race wins in the ALMS.[134]
For the 2008 season, Audi entered theLe Mans Series for the first time.Joest Racing entered two cars to compete againstPeugeot's two-car entry over the five race season. Peugeot led the championships early, winning the first three races prior to the24 Hours of Le Mans. A new sub-wing was introduced at Spa. This maintains the same level of downforce but less drag.
At Le Mans, Audi won for their third consecutive time with the R10. The No. 2 car driven byRinaldo Capello,Allan McNish andTom Kristensen took the chequered flag on lap 381 ahead of the No. 7Peugeot, with a margin of just over 4 minutes. The other two Audi entries finished fourth and sixth overall. Peugeot brought their seasoned 908 HDi FAP and qualified within the 3:18 range while Audi struggled to get under the 3:23 mark. In the race itself the Peugeot was still up to 3.5 seconds a lap faster but quick pit work by Audi and the superior performance by the R10 in the rain saw Audi winning Le Mans.
Returning to the Le Mans Series for the final two races of the year, Peugeot won once again at theNürburgring and maintaining their lead in the championships. However, accidents for Peugeot and a win by the No. 1 Audi ofRinaldo Capello andAllan McNish at theSilverstone finale allowed the Audi team to win the Constructors Championship, while the No. 2 Audi ofMike Rockenfeller andAlexandre Prémat earned the Drivers and Teams Championships.
Audi also continued their participation in the American Le Mans Series. As in the year before, Audi fought against thePenske RacingPorsches for overall race wins, but unlike before they now had to contend with the multipleAcura teams. Porsche managed to end Audi's streak of seven straight victories at the12 Hours of Sebring, but Audi rebounded with overall wins in the next two events. Three more overall victories were earned by Audi by time the series reached theDetroit Sports Car Challenge. Audi not only failed to win the race overall, but following a rule infraction, neither car finished in the LMP1 category. This was the first time that the Audi R10 failed to win in LMP1, and the first LMP1 loss by Audi since2005. At Petit Le Mans, Allan McNish overtook Christian Klien in the Peugeot on the penultimate lap and held on to the win.
In the 2009 season, the R10 TDI was replaced by theR15 TDI with a smaller, lighter, more-efficient TDI engine; however, Audi concentrated on the 24 Hours of Le Mans andDeutsche Tourenwagen Masters (DTM; German Touring Car Masters) efforts. The new car, however, ran in the 200912 Hours of Sebring before preparing for Le Mans. The Audi R10's wing was limited by the 2009 regulations. In early 2009,Colin Kolles announced that his team will run privately entered Audi R10 TDI's in that year's24 Hours of Le Mans, and possibly the Le Mans Series. The deal included factory assistance for servicing the cars.[10] At Le Mans, the Audi R10 best finished 7th overall, a few laps down on the highest petrol finisher Lola-Aston Martin which ranked 4th overall.
Kolles fielded 2 Audi R10 in their final year at the Le Mans 24 Hours, on 14 June 2010. Unlike the factory Audi and Peugeot LMP1, the Kolles R10 was not hampered by the new restrictor regulations which should have shaved off 60 bhp from the diesel-powered prototypes. The cars qualified 3:30, just behind the two Lola Astons. Both cars failed to finish because too much strain from torque was put onto the gearbox.
The 380 laps completed by the R10 was a new record in the number of laps completed, however, it did not surpass the distance record set byHelmut Marko andGijs van Lennep in the1971 24 Hours of Le Mans; that was broken by the R10's successor, the R15.[135] Along with theR8, the R10 remains one of Audi's most successful Le Mans prototypes, entering 48 races and winning 36.[136]
The R10 also won the 2006AutosportPioneering and Innovation Award, withJean Alesi andEddie Jordan presenting the award to Wolfgang Ullrich.[137]
Ultimately, changes that theAutomobile Club de l'Ouest (the organisation responsible for the 24 Hours of Le Mans) made to the regulations meant that Audi's successful open-cockpit lineage came to a close prior to the start of the 2011 season. Ullrich, despite his professed love for open-cockpit prototypes, explained how "the driver change [easier in an open car] is no longer the dominant factor in the time of the pit stop", and "It is getting more and more important to have maximum aerodynamic efficiency".[13] The capacity of turbodiesel engines was reduced from 5.5 L (335.6 cu in) to 3.7 L (225.8 cu in), as such, they produced less power, and aerodynamic efficiency played a bigger part in determining how quick a car was. Turbodiesel prototypes also received a further reduction in fuel tank capacity, from 81 L (21.4 US gal) to 63 L (16.6 US gal).[138]
Motor Sport magazine featured the 2008 Le Mans-winning trio of Capello, McNish, and Kristensen in a 2014 special,Great Racing Cars.[139] McNish recalled that "you really had to throw the R10 around", and "You had to attack, every single lap of the race, and the bizarre phenomenon was that you could race the car at the same speed as you did in qualifying."[32] Capello also reminisced about the visual design of the R10, saying that the R10's front fascia was "the most beautiful front end we had in the last 10 years at Audi Sport."[32]
(key) Races inbold indicatespole position. Races initalics indicates fastest lap.
| Year | Entrant | Class | Drivers | No. | Rds. | Rounds | Pts. | Pos. | |||||||||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| 1 | 2 | 3 | 4 | 5 | 6 | 7 | 8 | 9 | 10 | 11 | 12 | ||||||||
| 2006 |  Audi Sport North America | LMP1 |  Rinaldo Capello Allan McNish Tom Kristensen | 2 | 1, 5–10 1, 5–10 1 | SEB 1 | UTA 4 | PIR 1 | ELK 2 | MOS 1 | ATL 1 | LGA 1 | 215* | 1st | |||||
 Frank BielaEmanuele PirroMarco Werner | 1 | 1, 5–10 1, 5–10 1, 9 | SEB Ret | UTA 1 | PIR 2 | ELK 1 | MOS 4 | ATL 5 | LGA 2 | ||||||||||
| 2007 | Audi Sport North America | LMP1 | Rinaldo CapelloAllan McNishTom Kristensen | 1 | All All 1 | SEB 2 | STP 1 | LBH 1 | HOU 1 | UTA 1 | LIM 1 | MDO 2 | ELK 1 | MOS 1 | DET 2 | ATL 1 | LGA 1 | 258 | 1st |
| Marco WernerEmanuele PirroFrank BielaLucas LuhrMike Rockenfeller | 2 | All 1–10 1 11 12 | SEB 1 | STP 2 | LBH 2 | HOU 2 | UTA 2 | LIM 4 | MDO 1 | ELK 2 | MOS 2 | DET 1 | ATL 4 | LGA 2 | |||||
| 2008 | Audi Sport North America | LMP1 | Rinaldo CapelloAllan McNishTom KristensenEmanuele PirroFrank Biela Marcel Fässler Christijan Albers | 1 | 1, 5–6, 8, 10 1, 10 1 2–11 2–4 7, 9 11 | SEB 1 | STP Ret | LBH 2 | UTA 3** | LIM 3 | MDO 2 | ELK 2 | MOS 2 | DET DSQ | ATL 1 | LGA 2 | 230 | 1st | |
| Marco WernerLucas LuhrMike Rockenfeller | 2 | All All 1 | SEB 2 | STP 1 | LBH 1 | UTA 1 | LIM 1 | MDO 1 | ELK 1 | MOS 1 | DET Ret | ATL 3 | LGA 1 | ||||||
*60 points were scored with theR8 LMP.
**Despite retiring 17 laps behind the leader, they had completed over 70% of the winner's distance and were thus classified.
(key) Races inbold indicatespole position. Races initalics indicates fastest lap.
| Year | Entrant | Class | Drivers | No. | Rds. | Rounds | Pts. | Pos. | ||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|
| 1 | 2 | 3 | 4 | 5 | ||||||||
| 2008 | Audi Team Joest | LMP1 | Rinaldo CapelloAllan McNish | 1 | All All | CAT 5 | MON 6 | SPA 4 | NUR 4 | SIL 1 | 27 | 3rd |
 Alexandre PrématMike Rockenfeller | 2 | All All | CAT 2 | MON 2 | SPA 2 | NUR 3 | SIL 4 | 35 | 1st | |||
| 2009 | Kolles | LMP1 | Charles Zwolsman Jr.Andy Meyrick Narain KarthikeyanMichael Krumm | 14 | All All 1 2–5 | CAT 8 | SPA 6 | ALG NC | NUR 4 | SIL 6 | 12 | 7th |
| Christian BakkerudChristijan AlbersGiorgio Mondini | 15 | All All 2–4 | CAT Ret | SPA 7 | ALG Ret | NUR Ret | SIL 5 | 6 | 10th | |||
(key) Races inbold indicatespole position. Races initalics indicates fastest lap.
| Year | Team | Class | No. | Drivers | Position |
|---|---|---|---|---|---|
| 2006 | Audi Sport Team Joest | LMP1 | 8 | Frank BielaMarco WernerEmanuele Pirro | 1st |
| 7 | Rinaldo CapelloAllan McNishTom Kristensen | 3rd | |||
| 2007 | Audi Sport Team Joest | LMP1 | 3 | Lucas LuhrMike RockenfellerAlexandre Prémat | Ret |
| Audi Sport North America | 2 | Rinaldo CapelloAllan McNishTom Kristensen | Ret | ||
| 1 | Frank BielaMarco WernerEmanuele Pirro | 1st | |||
| 2008 | Audi Sport Team Joest | LMP1 | 3 | Lucas LuhrMike RockenfellerAlexandre Prémat | 4th |
| Audi Sport North America | 2 | Rinaldo CapelloAllan McNishTom Kristensen | 1st | ||
| 1 | Frank BielaMarco WernerEmanuele Pirro | 6th | |||
| 2009 | Kolles | LMP1 | 14 | Charles Zwolsman Jr.Narain KarthikeyanAndré Lotterer | 7th |
| 15 | Christian BakkerudChristijan AlbersGiorgio Mondini | 9th | |||
| 2010 | Kolles | LMP1 | 14 | Scott Tucker Manuel RodriguesChristophe Bouchut | Ret |
| 15 | Christian BakkerudChristijan AlbersOliver Jarvis | Ret |
| Awards | ||
|---|---|---|
| Preceded by | Autosport Pioneering and Innovation Award 2006 | Succeeded by |
| Subsidiaries |  | ||||
|---|---|---|---|---|---|
| Defunct brands |
| ||||
| Museums | |||||
| Current models |
| ||||
| AUDI |
| ||||
| Audi Sport |
| ||||
| Historic and discontinued models | |||||
| Motorsport |
| ||||
| Concept cars |
| ||||
| See also |
| ||||
